Andrew Ellis

Recently i replaced the t case on my 96 cherokee sport 4WD. It was running smoothly for 2 weeks and i did notice leaking from the rear of the t case. Driving home from school one day i began accelerating to about 60 then it started to feel like something flew up under my fender and started thumping so i pulled over. I waited and then took off agian and around 60 it did it agian. I pulled over agian and jumped out and looked under the jeep. The t case was letting off white smoke. I let it sit for a few days after driving it home and today i started it up and drove it and now theres a metal on metal scraping sound. I dont know much about cars at all but im guessing i just need to fix the seal on the t case then refill it with fluid but i rather get some adviced from more experienced people.
Thanks,
Andrew Ellis

tech

It sounds like the T case lost a bearing or something like that . you need to open it up and see what went wrong with it . or just change it .

DFlintstone

There are two large (7/8ths?) plugs on the rear of the TC. Lower is the drain, then the upper is filled with Dexron III tranny fluid till it overflows. You knew that, right?

Guywitha92

Mine were bigger than 7/8. An inch and something but I don't remember exactly. Or like 32mm

DFlintstone

10-4. I just remember them being big. I'm crashing. I'll assume yo have it full with DEX III then, is all I had.

cruiser54

Transfer case ran dry and is now FUBAR.

Andrew Ellis

So i should just buy a new transfer case?

cruiser54

A good used one.

And while you're at it, check every fluid level and condition on your Jeep.

Andrew Ellis

I was wondering if i could take the chain off my transfer case off and just run 2wd.(im broke and scraping is getting annoying) If i need to do more stuff to do to it what would it be? If im a f***inh idiot just tell me
Thanks

DFlintstone

Try just removing the front drive-line? If that's not turning it, and it's in 2 WD that might do it.