92 Cherokee Limited Project
#1
Newbie
Thread Starter
Join Date: Jan 2015
Location: Central Coast, Ca
Posts: 1
Likes: 0
Received 0 Likes
on
0 Posts
Year: 1992
Model: Cherokee
Engine: I6 4.0 HO
92 Cherokee Limited Project
I recently picked up a 92 XJ Limited. This will by my 3rd XJ but my only current one. Pretty much just making it into a fun toy for the dirt, creeks, mud and hills around here.
196k miles (rebuilt at 180k)
Inline 6 4.0HO
4x4 Selec-Trac
AW4 Automatic Transmission
Dana 30 Front
Dana 35C Rear
3.55 rear axle ratio
My priority is getting it mechanically sound before taking it out.
When I bought it:
Some photos of the work and current state of the vehicle.
So far I've done/installed:
Radiator
Thermostat
Water Pump
Coolant/Heater hoses
Passenger side fender
new bumper caps
oil pressure sending unit
all coolant senders & sensors (had to do a custom build for the gauge sender)
Roof rack
50" LED Light bar
Snorkel Kit
Removed damaged fender.
My jeep didn't have the temperature gauge sending unit where it was supposed to be so I extended the cable, built it into this setup. Works great!
A little bit of paint:
Drilling for the snorkel kit:
Snorkel finished:
LED Lights installed:
I still have a ton of work to do but having fun with it so far. Much easier to work on the my 2000 WJ.
My upcoming projects are:
Run better wiring for LED Light bar (PO had wiring in place but its a little small).
Fix headliner
fix power locks (they lock but don't unlock) any ideas?
install CB and other radios
new coolant tank
new washer fluid tank
new rear tires
new rear seatbelt (driver side)
run new wiring to grille and rear for small lights
fix leaking sunroof... (debating if I should just seal it or figure out why and where its leaking)...
Hope you enjoy the pics! If you have any suggestions or tips I'm always happy to listen and learn!
196k miles (rebuilt at 180k)
Inline 6 4.0HO
4x4 Selec-Trac
AW4 Automatic Transmission
Dana 30 Front
Dana 35C Rear
3.55 rear axle ratio
My priority is getting it mechanically sound before taking it out.
When I bought it:
Some photos of the work and current state of the vehicle.
So far I've done/installed:
Radiator
Thermostat
Water Pump
Coolant/Heater hoses
Passenger side fender
new bumper caps
oil pressure sending unit
all coolant senders & sensors (had to do a custom build for the gauge sender)
Roof rack
50" LED Light bar
Snorkel Kit
Removed damaged fender.
My jeep didn't have the temperature gauge sending unit where it was supposed to be so I extended the cable, built it into this setup. Works great!
A little bit of paint:
Drilling for the snorkel kit:
Snorkel finished:
LED Lights installed:
I still have a ton of work to do but having fun with it so far. Much easier to work on the my 2000 WJ.
My upcoming projects are:
Run better wiring for LED Light bar (PO had wiring in place but its a little small).
Fix headliner
fix power locks (they lock but don't unlock) any ideas?
install CB and other radios
new coolant tank
new washer fluid tank
new rear tires
new rear seatbelt (driver side)
run new wiring to grille and rear for small lights
fix leaking sunroof... (debating if I should just seal it or figure out why and where its leaking)...
Hope you enjoy the pics! If you have any suggestions or tips I'm always happy to listen and learn!
Last edited by jasonhcc; 02-08-2015 at 07:04 PM.
Thread
Thread Starter
Forum
Replies
Last Post
98JGC826
Stock Grand Cherokee Tech. All ZJ/WJ/WK Non-modified/stock questions go here!
10
08-29-2015 04:51 PM
csmith237
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
2
08-24-2015 12:54 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)