My 96 ZJ doesn't like my summer holiday
#1
Member
Thread Starter
My 96 ZJ doesn't like my summer holiday
Last summer half way in the holiday trip, the cooler started leaking. We could finish the trip, but I had to refill 2liters/50km.
Tomorrow we are going to leave for holiday, and guess what happened? Yes you are right, today when I arrived home the coolant started to boil. I have checked, there is no leak, after it cooled down it sucked back the coolant properly from the overflow tank, so my only idea was the thermostat. I have remove it, it's a 195F one. Started to heat it in water, it was boiling for a while, when it finally started to open, but only for 2mm.
So I decided to do the trip without it, anyway it's a real hot summer, I tested with climate the temp is not higher than 180F.
By the way it's real good fun to remove the thermostat housing in the L6 engine .
Any ideas what brand should I by, after we returned?
Tomorrow we are going to leave for holiday, and guess what happened? Yes you are right, today when I arrived home the coolant started to boil. I have checked, there is no leak, after it cooled down it sucked back the coolant properly from the overflow tank, so my only idea was the thermostat. I have remove it, it's a 195F one. Started to heat it in water, it was boiling for a while, when it finally started to open, but only for 2mm.
So I decided to do the trip without it, anyway it's a real hot summer, I tested with climate the temp is not higher than 180F.
By the way it's real good fun to remove the thermostat housing in the L6 engine .
Any ideas what brand should I by, after we returned?
#2
Old fart with a wrench
I don't know what brands are available to you, but I've always used Stant Superstats when I can find them. I'm told that Auto Zone aren't bad either.
#3
Member
Thread Starter
We did the trip successfully, the temp was not higher than 180F even with climate on the highway, so it seams really only the t-state was faulty, I will replace it soon. I have found Stant at RockAuto, what is your opinion about the opening temp, does it make any sense to go lower (180; 160F) or I should keep the original 195F?
Thread
Thread Starter
Forum
Replies
Last Post
NCDON
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
20
05-05-2021 07:44 PM
daddytuck
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
0
09-07-2015 08:16 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)