96 zj 42re no reverse & clicks in overdrive
#1
Newbie
Thread Starter
Join Date: Mar 2010
Location: klamath fallf or.
Posts: 16
Likes: 0
Received 0 Likes
on
0 Posts
Year: 85
Model: Cherokee
Engine: 2.5 4 barrel intake cam header
96 zj 42re no reverse & clicks in overdrive
I first noticed it was holding first gear to long occasionally. then I went to back out of drv way and it didn't fully engage in revers pulls slightly and drags motor down just briefly when I revved it up it started clicking loudly and stopped when I put in neutral. it goes forward and does not hold rpm when I let off throttle engine goes back to idle in all 4 gears and it starts clicking shortly after fourth gear engages till I push o/d button and it goes back in third
#2
Senior Member
Join Date: Dec 2010
Location: Norman, OK
Posts: 698
Likes: 0
Received 2 Likes
on
2 Posts
Year: 95
Model: Grand Cherokee
Engine: 4.0
Sounds like the direct-O/D clutch snap ring failure, its pretty common for the snap ring to break into pieces. Another symptom would be to shift it into manual 1st gear and speed up and slow down, if you dont have engine braking its probably broken. Usually pieces of the broken snap ring will fall into the pan so you might want to drop the pan and check.
If this is the problem you can repair it by removing the O/D unit, either rebuild it yourself or have a trans shop go through it. Price around because it should'nt be real expensive.
If this is the problem you can repair it by removing the O/D unit, either rebuild it yourself or have a trans shop go through it. Price around because it should'nt be real expensive.
Thread
Thread Starter
Forum
Replies
Last Post
Blue94xj
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
20
04-16-2023 10:20 AM
jmsummers2012
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
53
04-30-2021 02:35 PM
xjcarolina
Stock XJ Cherokee Tech. All XJ Non-modified/stock questions go here
5
09-29-2015 08:43 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)