my89xj

Well I'm pretty sure my seals are bad. After putting the car in 4low for the first time in it's life i think they blew. I searched for a how to write but could only find rear axle. I have an 89 xj.

Turbo X_J

What symptoms?

my89xj

You first see how some shot onto my tire,and them I show were all the fluid is sitting.

RenegadeT

the front seals are all the way in the center housing. Cliff notes...remove diff cover, drain gear oil, then to then remove wheels, brakes, unit hub w/axle shaft attached. Back to the center, pull the carrier, with a long stick/pole knock the seals from outside in, pop new seals in, reassemble.

RenegadeT

oops...89XJ...you should have the passenger side disconnect axle, that adds a little confusion, but same general steps I outlined.
http://www.stu-offroad.com/axle/yjd3...jconvert-1.htm
^ might help you understand what you're getting into

my89xj

So am i ok to drive with them as long as I don't go into 4. And there's to seals which ones do i change? And since mines an 89 it shouldn't have the vacum?

my89xj

Ok so I've done some research I do.t have the vacuum, but there's the inner outer and tube seal, I'm guessing if its leaking there all bad?

Turbo X_J

If there is an outer & inner the best idea is to replace both seals while your there.

my89xj

This is the website i always use to order parts, i just dont know what i need, theres a hundred different seals listed.http://www.jeep4x4center.com/jeep-ax...herokee-xj.htm

Turbo X_J

First is it a Dana 30 w or wo vacuum disconnect? If you don't know take a pic.

my89xj

I'm positive its without vacuum, ill take a pic regardless.

hbracing13

When you see it you'll know if you have the vac or not. If it not vac the seals are super easy to R&R . If vac unit the dirver side is easy the passanger side is a different story I have to make a tool to get that seal in.

Radi

Watch to make sure the axle doesn't run dry, and that the brake pads don't get wet.
Mine is leaking very slightly too....I have it on the round 'tuit list for now. Not quite bad enough to motivate me and I have to do the u-joints anyway....

Good luck!

XJcountry

Here is a link to how to do it.. http://naxja.net/forum/showthread.php?t=937821

my89xj

Do you guys have some brands you trust, I don't really know what's good and what's not, also I'm on a highschool budget